DC Solar Centrifugal Pump | SCPM Series Solar Surface Pump Permanent magnet brushless DC Solar water Pump DC48V,DC72V Solar pumping system Solar panel:2 - 6 pieces Poly / Mono 250/300 watt solar panel Power range:370 - 1100w Head range:15 - 35m Flow range:4.8 - 27 m3/h Pump Inlet/Outlet:1"×1",1.25"×1",1.5"×1.5",2"×2"
DC Solar surface pumps are fitted with a permanent magnet,brushless motor, Which enables the efficient use of energy from a wide range of supply options. The pump system offers the perfect water supply solution. This project products are mainly used in dry irrigation of agriculture. It can be used for drinking water and living water. The living condition could be much improved.
1. Permanent magnet,brushless motor,saving energy and offering maximum efficiency. 2. NSK bearing with alloy mechanical seal,offering the longer working life. 3. MPPT function offers higher utilization rate of solar energy. 4. Water proof and leak proof based on double water seal. 5. Controller maximum's operating temperature:60℃ 6. Featured function:MPPT function,Soft start function,Dry running protection,Adjustable speed function, Error wiring protection,Over/under-voltage protection,Overload protection,Over-current protection, phase-loss protection,High working temperature protection
1.Power Supply: .Solar panel,Storage batteries. DC48 Solar pumps:42-100V (VMP) DC72 Solar pumps:63-150V (VMP) 2.Water temperature:≤35℃ 3.PH value 6.5 ~ 8.0
|Volatge (V)||Power (W)||Vmp (V)||Max.Flow (m3/h)||Max.Head (m)||Outlet / Inlet (Inch)|
AQUAROYAL SCPM series solar centrifugal pump which get the power from the sun, you will never have an electric bill,SCPM series solar centrifugal pump can not only be used for household drinking water, but for animal husbandry and irrigation of small farms. which is a mechanical device designed to move a fluid by means of the transfer of rotational energy from impeller.Fluid enters the rapidly rotating impeller along its axis and is cast out by centrifugal force along it’s circumference through the impeller’s vane tips.The action of the impeller increases the fluid’s velocity and pressure and also directs it towards the pump outlet.The pump casing is specially designed to constrict the fluid from the pump inlet,direct it into the impeller and then slow and control the fluid before discharge..
AQUAROYAL SCPM series centrifugal pump consists of SS304 impeller,SS304/Cast iron pump head,Aluminum pump casing,Brushless DC motor(BLDC motor),3 meters,3 cores,1.5mm2 cable and controller with installation tools.As accessories which include float switch,non-return valve,shrinkable tubes,adhesive tape,operation manual.
AQUAROYAL BLDC motor which mainly consists of stator and rotor.For the stator which consists of silicon steel sheet & high temperature copper wire.Whose the max temperature is 180 degrees. All winding automatically by machine,which can produce about 2000 pieces per day.For the rotor which includes NSK bearing,SS 304 shaft and 40SH magnet.Whose the max temperature is 150 degrees.
MPPT function Maximum Power Point Tracking is electronic tracking - usually digital. The charge controller looks at the output of the panels and compares it to the battery voltage. It then figures out what is the best power that the panel can put out to charge the battery. It takes this and converts it to best voltage to get maximum AMPS into the battery. (Remember, it is Amps into the battery that counts). Most modern MPPT's are around 93-97% efficient in the conversion. You typically get a 20 to 45% power gain in winter and 10-15% in summer. Actual gain can vary widely depending weather, temperature, battery state of charge, and other factors. Soft start function AQUAROYAL controller control the the motor operation continues,operting power is gradually increased until motor reaches it;s maximum speed.As a result,service lifetime of both the motor and controller and protection switch gear and prolonged. Dry running protection AQUAROYAL solar submersible pump’s controller that offers intelligent detection function of water level.when the water level dropped below the pump inlet, the AQUAROYAL controller will stop the pump and indicates Well LED. Stop the pump automatically,Restarts automatically 30mins,Flexible installation. Adjustable speed function AQUAROYAL solar pump’s controller with adjustable speed function. User could set different working speed to adjust water capacity and head according actual water demand to avoid water waste. Meanwhile,which also reduces the mechanical wear of the motor as well as the start up loads on the PV array. Self-protecting functions Error wiring protection Over/under-voltage protection Overload protection Over-current protection phase-loss protection High working temperature protection
AQUAROYAL use SS304 impeller which is corrosion resistant due to the addition of chromium (minimum 10.5%) to the alloy.The chromium reacts with oxygen forming a chromium oxide barrier, shielding the iron from environmental oxygen and water. Nickel is also usually present in alloys of stainless steel to improve ductility.
Hereby guarantee that AQUAROYAL solar SCPM solar pump are guaranteed against defects in material and technology for 24 months beginning from the date of shipping the goods from factory.Within this period,adjustment,repair or replacement of parts or whole will be performed without charge except in the case of damage caused by accidents,misuse,tampering or lack of care. 2.Not under warranty 1)Defects caused by the owner's neglect of instructions in the manual before operation or misuse of the pump. 2).Operation on higher/lower voltage than specified,tampering with electrical system,voltage surges as a result of lightening or faulty electrical supply. 3).Any damage caused by natural disasters,such as fire,flood or earthquake. 4).The pump tampered with or damaged by any non-authorized technician. 5).Maximum fluid temperature exceed 35 degrees celsius. 6).Maximum sand content exceed 0.25%. 7).Putting water inside the controller by user.
AQUAROYAL always insists to provide best service,the delivery time is about 2 weeks.
AQUAROYAL could according your demand to select the loading port,Normally we choose Ningbo port.
Your surface pump with large flow, which is very suitable for my agricultural irrigation，Thanks